Product ID:SPRAY GRAY PRIMER, 46-0860080
MSDS Date:04/14/1988
FSC:8010
NIIN:00N020975
MSDS Number: BLJCD

VALSPAR CORP

1101 THIRD ST SOUTH
MINNEAPOLIS, MN 55415
US

Emergency Phone: 800-228-5635

Info Phone: 612-332-7371

Cage: 13374

VALSPAR CORPORATION

MINNEAPOLIS, MN 55415 US

Telephone: 612-332-7371/888-345-5732

Cage: 23526

SOLVENT NAPHTHA, (PETROLEUM) LIGHT ALIPHATIC

CAS: 64742-89-8

Fraction By Weight: 5-10%

OSHA PEL 300 PPM;500 PPM STEL

ACGIH TLV: 300 PPM;500 PPM STEL

PROPELLANT MIXTURE OF INGREDIENTS 5, 6, 7

RTECS: 9999999ZZ

Fraction By Weight: 25%

PROPANE

CAS: 74-98-6

RTECS: TX2275000

OSHA PEL 1000 PPM

ACGIH TLV: ASPHYXIANT; 9192

PROPANE, 2-METHYL-; (2-METHYLPROPANE)

CAS: 75-28-5

RTECS: TZ4300000

BUTANE

CAS: 106-97-8

RTECS: EJ4200000

OSHA PEL 800 PPM

ACGIH TLV: 800 PPM; 9192

WEAR RESPIRATORY PROTECTION (NIOSH/MSHA TC23C OR

RTECS: 9999999ZZ

ACETONE (SARA III)

CAS: 67-64-1

RTECS: AL3150000

Fraction By Weight: 10-15%

OSHA PEL 1000PPM

ACGIH TLV: 750PPM/1000STEL;9293

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

XYLENES (O-,M-,P- ISOMERS) (SARA III)

CAS: 1330-20-7

RTECS: ZE2100000

Fraction By Weight: 30-35%

OSHA PEL 100 PPM/150 STEL

ACGIH TLV: 100 PPM/150STEL;9192

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHAL: EXCESSIVE INHAL OF VAPS
CAN CAUSE NASAL & RESPIRATORY IRRIT, DIZZ, WEAK, FATG, NAUS, HDACH,
POSS UNCON & EVEN ASPHYXIATION. EYE: CAN CAUSE SEVERE IRRIT,
REDNESS, TEARING, BLURRED VISION. INGEST: CAN CAUSE GI IRRIT,
NAUS, VOMIT, DIARR. SKIN: CAN CAUSE IRRIT FOR SOME PERSONS. (EFTS
OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: CHRONIC: REPORTS HAVE ASSOC RPTD/
PRLNG OCCUP OVEREXPOSURE TO SOLVENTS W/PERM BRAIN & NERVOUS SYSTEM
DAMAGE. SEVERE OVEREXP IN LAB ANIMALS HAS ALSO CAUSE LIVER
ABNORMALITIES & DAMAGE TO KIDN EYS, LUNGS, & SPLEEN. INTENTIONAL
MISUSE BY DELIVERATELY CONCENTRATING & INHALING THE CONTENTS MAY BE
HARMFUL OR FATAL.
Medical Cond Aggravated by Exposure:ANY RESPIRATORY OR SKIN CONDITION.

First Aid:INGEST: DO NOT INDUCE VOMIT. KEEP PERSON WARM/QUIET & GET MED
ATTN. ASPIR OF MATL INTO THE LUNGS DUE TO VOMIT CAN CAUSE CHEM
PNEUMIT WHICH CAN BE FATAL. INHAL: REMOVE TO FRESH AIR. IF BRTHG IS
DFCLT, ADMINISTER O2. IF BRTHG HAS STOPPED, GIVE ARTF RESP. KEEP
PERSON WARM/QUIET & GET MED ATTN. EYES: FLUSH W/WATER FOR A MINIMUM
OF 15 MIN WHILE OCCAS HOLDING EYELIDS OPEN. GET MED ATTN. (SUPP
DATA)

Flash Point Method:TCC
Flash Point:0F,-18C
Lower Limits:1%
Extinguishing Media:CO2, DRY CHEMICAL OR ALCOHOL FOAM.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP
. WATER MAY BE USED TO COOL CLOSED CONTRS TO PVNT PRESS BUILD- UP &
POSS AUTOIGNIT/EXPLOSION WHEN (SUPP DATA
Unusual Fire/Explosion Hazard:VAPS ARE HEAVIER THAN AIR & MAY TRAVEL
ALONG THE GROUND OR MAY BE MOVED BY VENT & IGNITED BY PILOT LIGHTS,
HEATERS, SMKNG, ELECTRIC MOTORS OR OTHER (SUPP DATA)

Spill Release Procedures:ABSORB LIQUID ON PAPER, VERMICULITE, FLOOR
ABSORBENT, OR OTHER ABSORBENT MATL & TRANSFER TO CLOSED CONTR.
ELIMINATE ALL IGNITION SOURCES.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:DO NOT STORE IN AREAS ABOVE 120F OR IN
DIRECT SUNLIGHT OR NEAR HEAT OR OPEN FLAME. DO NOT PUNCTURE OR
INCINERATE.
Other Precautions:STORE LARGE QUANTITIES IN BUILDINGS PROTECTED FOR
STORAGE OF NFPA CLASS 1C FLAMMABLE LIQUIDS.

Respiratory Protection:FOR CASUAL/OCCASIONAL USE: TO AVOID BRTHG
VAPORS/ SPRAY MISTS, OPEN WINDOWS/DOORS OR USE OTHER MEANS TO
ENSURE FRESH AIR ENTRY DURING APPLICATION/DRYING. IF YOU EXPERIENCE
EYE WATERING, HEADACHE, OR D IZZINESS, INCREASE FRESH AIR OR (ING
8)
Ventilation:FOR REGULAR/CONTINUOUS USE: PROVIDE SUFFICIENT MECH
(GENERAL) VENT &/OR LOCAL EXHAUST TO MAINTAIN EXPOSURE BELOW TLV'S.
Protective Gloves:CHEMICAL RESISTANT GLOVES.
Eye Protection:CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:WHERE SPECIAL OR UNUSUAL CONDITIONS EXIST,
THE EXPERT ASSISTANCE OF AN INDUSTRIAL HYGIENIST SHOULD BE SOUGHT.
Work Hygienic Practices:WASH CLOTHING BEFORE RE-USE.
Supplemental Safety and Health
FIRE FIGHT PROC: EXPOSED TO EXTREME HEAT. IF WATER IS USED, FOG NOZZ
ARE PREF. EXPLO HAZ: IGNITION SOURCES AT LOCATIONS DISTANT FROM
MATL HNDLG PT. CLOSED CONTRS MAY EXPLODE &/OR AUTOIGNITE WHEN EXPOS
ED TO EXTREME HEAT. FIRST AID PROC: SKIN: WASH W/SOAP & WATER OR
VARIOUS HAND CLEANERS, & WASH CLTHG BEFORE RE-USE.

HCC:V3
Boiling Pt:B.P. Text:133F,56C
Vapor Pres:186 @20C
Vapor Density:HVR/AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:SLIGHT TO MODERATE
Appearance and Odor:TYPICAL SOLVENT PAINT.
Percent Volatiles by Volume:85-90

Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDIZING AGENTS AND HEAT.
Stability Condition to Avoid:HEAT, SPARKS AND OPEN FLAME.
Hazardous Decomposition Products:MAY FORM TOXIC MATLS: CO2/CO, VARIOUS
HYDROCARBONS, ETC. WHEN BURNED.

Waste Disposal Methods:MATERIAL COLLECTED ON ABSORBENT MATERIAL MAY BE
DEPOSITED IN A POSTED TOXIC SUBSTANCE LANDFILL IN ACCORDANCE WITH
LOCAL, STATE, AND FEDERAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.